Table of Contents
Advertisement
Troubleshooting
Perform only the steps described in these instructions. All further inspection, maintenance, and repair work
must be performed by an authorized Toro distributor or a similarly qualified specialist if you cannot solve the
problem yourself.
Problem
The machine does not start.
The machine does not run or does not run
continuously.
The machine does not reach full power.
The battery pack(s) lose charge quickly.
The battery charger is not working.
The LED indicator light on the battery
charger is red.
The LED indicator light on the battery
charger is blinking red.
Possible Cause
1. The battery packs are not fully installed
in the machine.
2. The battery packs are not charged.
3. The battery packs are damaged.
4. There is another electrical problem
with the machine.
1. There is moisture on the leads of the
battery packs.
2. The battery packs are not fully installed
into the machine.
1. The battery pack charge capacity is
too low.
2. The battery pack air vents are blocked.
1. The battery packs are over or under
the appropriate temperature range.
2. The machine is overloaded.
1. The battery charger is over or under
the appropriate temperature range.
2. The outlet that the battery charger is
plugged into does not have power.
1. The battery charger and/or battery
pack is over or under the appropriate
temperature range.
1. There is an error in the communication
between the battery pack and the
charger.
2. The battery pack is weak.
27
Corrective Action
1. Remove and then replace the battery
packs into the machine, making sure
that they are fully installed and latched.
2. Remove the battery packs from the
machine and charge them.
3. Replace the battery packs.
4. Contact an authorized Toro distributor.
1. Allow the battery packs to dry or wipe
them dry.
2. Remove and then replace the battery
packs into the machine, making sure
that they are fully installed and latched.
1. Remove the battery packs from the
machine and fully charge the battery
packs.
2. Clean the air vents.
1. Move the battery packs to a place
where it is dry and the temperature is
between 5°C (41°F) and 40°C (104°F).
2. Cut the grass at a higher height of cut
or walk at a slower pace while mowing.
1. Unplug the battery charger and move
it to a place where it is dry and the
temperature is between 5°C (41°F)
and 40°C (104°F).
2. Contact your licensed electrician to
repair the outlet.
1. Unplug the battery charger and move
the battery charger and battery pack
to a place where it is dry and the
temperature is between 5°C (41°F)
and 40°C (104°F).
1. Remove the battery pack from the
battery charger, unplug the battery
charger from the outlet, and wait 10
seconds. Plug the battery charger into
the outlet again and place the battery
pack on the battery charger. If the LED
indicator light on the battery charger is
still blinking red, repeat this procedure
again. If the LED indicator light on
the battery charger is still blinking red
after 2 attempts, properly dispose of
the battery pack at a battery recycling
facility.
2. Contact your authorized Toro distributor
if the battery is in warranty, or properly
dispose of the battery pack at a battery
recycling facility.
Advertisement
Table of Contents
